Product ID:ABLEBOND 36-2, 83-4003
MSDS Date:05/06/1994
FSC:8040
NIIN:01-101-5662
MSDS Number: CCPHT

ABLESTIK LABORATORIES

20021 SUSANA ROAD
RANCHO DOMINGUEZ, CA 90221
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 213-764-4600

Preparer: SHARON OPPELT

Cage: 9V874

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

COMPTON, CA 90221 US

Telephone: 310-764-4600

Cage: 21109

RESORCINOL, DIGLYCIDYL-; (RESORCINOL DIGLYCIDYL ETHER) LD50

CAS: 101-90-6

RTECS: VH1050000

Fraction By Weight: 10-15%

OSHA PEL N/K

ACGIH TLV: N/K

PHENOL, 4,4'-ISOPROPYLIDENEDI-; (BISPHENOL A) (SARA 313)

CAS: 80-05-7

RTECS: SL6300000

Fraction By Weight: 1-5%

OSHA PEL N/K

ACGIH TLV: N/K

7-OXABICYCLO (4.1.0) HEPTANE, 3-(EPOXYETHYL-);

CAS: 106-87-6

RTECS: RN8640000

Fraction By Weight: 1-5%

OSHA PEL S, 10 PPM

ACGIH TLV: S, 10 PPM; A2; 9495

SILVER (SARA 313) (CERCLA)

CAS: 7440-22-4

RTECS: VW3500000

Fraction By Weight: 60-75%

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.1 MG/M3; 9495

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

< 100 G/L

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

SEVERELY IRRIT. IF NOT REMOVED PROMPTLY, WILL

RTECS: 9999999ZZ

THIS CHEM WAS FOUND TO BE POSITIVE IN

RTECS: 9999999ZZ

MILD SKIN IRRIT.

RTECS: 9999999ZZ

IRRIT

RTECS: 9999999ZZ

IRRIT, & MAY INJURE EYE TISS

RTECS: 9999999ZZ

MAY CAUSE GI

RTECS: 9999999ZZ

TOX THROUGH THE SKIN. IRRIT TO THE SKIN. MAY CAUSE

RTECS: 9999999ZZ

IRRIT TO

RTECS: 9999999ZZ

MAY BE FORMED AT ELEVATED TEMP MAY BE IRRIT TO EYES

RTECS: 9999999ZZ

WILL CAUSE BURNS & PERM TISS DMG. OTHER NOTES ON

RTECS: 9999999ZZ

MUTAGENETIC ASSAYS. POSSIBLE CANCER HAZARD.

RTECS: 9999999ZZ

PERSON. TREAT SYMPTOMATICALLY AND

RTECS: 9999999ZZ

IF CONTACT OCCURRED, WASH WITH SOAP AND WATER

RTECS: 9999999ZZ

GROUP 2B. NTP 7TH ANNUAL REPORT ON

RTECS: 9999999ZZ

IARC MONOGRAPHS,

RTECS: 9999999ZZ

ANTICIPATED TO BE

RTECS: 9999999ZZ

AND EQUIPMENT TO PREVENT ANY POSSIBILITY

RTECS: 9999999ZZ

LD50 LC50 Mixture:SEE INGREDIENTS
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE:IRRIT, & MAY INJURE EYE
TISS IF NOT REMOVED PROMPTLY. SKIN:MOD SYSTEMIC TOX THRU THE SKIN.
MAY CAUSE SKIN SENSIT, A PARTIAL/WHOLE-BODY DERMATITIC RASH EXPERD
AFTER EXPOS, HOWEVER MINIMAL. I NHAL:IRRIT &/TOX VAPS MAY BE RELS
AT ELEVATED TEMPS. VAPS MAY BE IRRIT TO RESP SYS & NASAL PASSAGES.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:VINYL CYCLOHEXENE DIOXIDE:IARC
MONOGRAPHS ON THE EVALUATION OF CARCINOGENIC RISK OF CHEM TO MAN
VOL 60, PG 361,(ING 19)
Effects of Overexposure:HLTH HAZ: IF CURED MATL IS SANDED RSLTG POWDER
WOULD BE CONSIDERED HAZ. INGEST:EFTS HAVE NOT BEEN EVALUATED BUT
ARE ASSUMED TO CAUSE NAUSEA & VOMIT. CHRONIC: PRLNG/RPTD CNTCT
W/SKIN CAN CAUSE SENSIT. TARGET ORGANS: SKIN; EYES. TOXICOLOGY
INFO:RAW MATL NAME:NOTES ON DERMAL TOX:SEVERELY IRRIT; MAY CAUSE
PERM (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:IMMED FLUSH EYES W/LARGE AMTS OF H*2O FOR AT LEAST 15
MIN, LIFTING UPPER & LOWER LIDS. GET PROMPT MED ATTN. SKIN:FLUSH
EXPOSED AREAS THOROUGHLY W/SOAP & H*2O UNTIL ALL CHEM IS REMOVED.
REMOVE CONT AMD CLTHG & LAUNDER BEFORE REUSE. IF IRRIT PERSISTS,
GET MED ATTN. INHAL:REMOVE TO FRESH AIR. GET MED ATTN IF IRRIT
PERSISTS. INGEST:DO NOT ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN
UNCON (ING 17)

Flash Point Method:COC
Flash Point:230F,110C
Extinguishing Media:CO*2; DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:EMITS TOXIC FUMES UNDER FIRE CONDITIONS.

Spill Release Procedures:SCRAPE UP AND PLACE IN SUITABLE LABELED
CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STOR TEMP:-40 DEGREE F. SPECIAL
SENSITIVITY:HEAT. EMPTY CNTNRS MAY CNTN PROD RESIDUE; FOLLOW MSDS &
LABEL WARNINGS EVEN AFTER THEY HAVE BEEN EMPTIED.
Other Precautions:PROD CAN ONLY BE USED FOR THIN BOND LINE
APPLICATION/RAPID EXOTHERMIC CURING REACTION MAY RESULT.

Respiratory Protection:NIOSH APPROVED RESPIRATOR IF REQUIRED. NIOSH
APPROVED SELF-CONTAINED BREATHING APPARATUS IN EMERGENCY AND
NON-ROUTINE SITUATIONS.
Ventilation:VENT CURING OVEN TO OUTDOORS.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
CLOTHING REQUIREMENTS:EMPLOYEE MUST WEAR APPROP PROT CLTHG (ING 22)
Work Hygienic Practices:IF PROD IS SPILLED ON CLOTHES, REMOVE IMMED &
LAUNDER BEFORE REUSE. WASH SEPERATELY FROM OTHER CLOTHES. (ING 18)
Supplemental Safety and Health
EFTS OF OVEREXP:SKIN DMG. MAY CAUSE SKIN SENSIT, A PARTIAL OR
WHOLE-BODY DERMATITIC RASH EXPERIENCED AFTER EXPOS, HOWEVER
MINIMAL. INHAL:VAPS &/AEROSOLS WHICH MAY BE FORMED AT ELEVATED TEMP
MAY BE IRR IT TO EYES & RESP TRACT. VAPS &/AEROSOLS WHICH MAY BE
FORMED AT ELEVATED TEMP MAY CAUSE SYSTEMIC EFTS. (ING 6)

Spec Gravity:3.200 (H*2O=1)
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:SILVER PASTE; PLEASANT ODOR
Percent Volatiles by Volume:NIL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN & UNKNOWN ORGANICS. THERMAL DECOMPOSITION
PRODUCTS ARE HAZ &/TOXIC.

Waste Disposal Methods:WASTE DISPOSAL SHOULD BE IN ACCORDANCE WITH
EXISTING FEDERAL, STATE AND LOCAL ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.